graded quarry dust in concrete

Partial Replacement of Sand by Quarry Dust in Concrete

Partial Replacement of Sand by Quarry Dust in Concrete

Graded Stone With Quarry Dust Quarry dust quarry dust suppliers and manufacturers mining stone quarries in singapore quarry dust wholesale various high quality quarry dust products from global quarry mini cone crusher in singapore for salegranite cone crusher dust seal for sale he most popular mining industry stone hammer crusher dust Concrete with quarry dust as fine aggregate In a study in Thailand by Khamput 11 on the compressive strength of concrete using quarry dust as fine aggregate and mixing with admixture type E it was found that with 70 quarry dust the concrete produced compared well with normal concrete He recommended quarry dust for

Get More

Study of Concrete Involving Use of Quarry dust as

Study of Concrete Involving Use of Quarry dust as

quarry dust M 4 40 quarry dust M 5 50 quarry dust respectively The variations of slump value with quarry dust percentage are shown in Figureure 1 It is observed that the slump value increases with increase in percentage replacement of sand with quarry dust for the same wc ratio Concrete does not give adequate increase in quarry dust content Quarry dust particles absorbed more water as compared to sand and thus negatively impacting the workability of concrete mix Slump was minimum for the concrete mixture containing 40 quarry dust in place of fine aggregates The variation of slump with quarry dust content is depicted in Fig 3

Get More

Graded Stone With Quarry Dust Krosline

Graded Stone With Quarry Dust Krosline

Quarry dust is a result of crushers while doing quarrying activities Quarry dust was obtained from nearby quarries at thehomeplaceslikeParitalaregionKanchikacherlamandal Vijayawada rural e present investigations are aimed at studying the e ect of quarry dust when it is replaced with sand partially in concrete e quarry dust samples concrete before and after setting on each replacement of sand by quarry dust in M20 and M25 grade of concrete And to find out if Quarry dust is a suitable replacement of sand or not From this experimental result it is obtained that the 40 of sand replaced by quarry dust in concrete

Get More

Effect of Quarry Dust on High Performance Concrete

Effect of Quarry Dust on High Performance Concrete

32 QUARRY DUST Quarry dusts are also one of the main ingredients of the Geopolymer concrete which helps in bonding between aggregate and fly ash properly The size of Quarry dust is used in work is lower than 475mm sieve IS383 1963 defined the Quarry dust which will passes through 475mm IS sieve and retained over 75 IS sieve is known work is an attempt to use Quarry Dust as replacement for Sand Attempts have been made to study the basic properties of Quarry dust and compressive strength of Quarry dust concrete The quarry dust behaves similar to conventional fine aggregate sand with respect to

Get More

Analysis of Concrete Made from Quarry Dust

Analysis of Concrete Made from Quarry Dust

investigated the partial replacement of sand with quarry dust Initially cement concrete cube was studied with various proportions of cement concrete quarry dust M 20 AND M25 The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30 40 and 50 was found to enhance the compressive properties Unfortunately the effect of quarry dust content in aggregates on properties of fresh and hardened concrete are not well known Tahir and Khaled 1999 A huge amount of quarry dust produced during the crushing of quarry stones in the quarry industries is often considered as waste and is often used as landfills Rashid at el 2013

Get More

Implication of Metakaolin in Quarry Dust Concrete

Implication of Metakaolin in Quarry Dust Concrete

Nov 15 2012 graded quarry dust in concrete Mechanical Properties of Foamed Concrete A foamed concrete of M20 grade could be obtained by using a cement of 468 kgm3 sand 234 kgm3 quarry dust 234 kg More detailed quarry dust is reduced by the addition fly ash This paper investigates the workability and strength characteristics of Quarry Dust Concrete QDC containing 0 to 30 of fly ash Based on the test results it can be concluded that combined use of quarry dust and fly ash can be shown improved strength in concrete and also

Get More

High performance concrete using quarry dust as fine

High performance concrete using quarry dust as fine

concluded that the compressive strength of concrete with 50 Sand and 50 quarry dust Mix 3 under thermo shock and high temperature showed the least reduction in strength It was finally concluded that quarry dust can be effectively used for 50 replacement of sand in the conventional concrete Utilization of Quarry Dust as Fine Aggregates V The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied M25 grade concrete was prepared with 0 20 40 60 80 partial replacement of sand with quarry dust The physical properties of quarry dust namely

Get More

Optimum utilization of Quarry dust as partial

Optimum utilization of Quarry dust as partial

Unlike other waste by products quarry dust is the waste material found from the crushing process of the stones and available abundantly from rock quarries at low cost2 Quarry dust may cause negative impact on environment 3 Quarry dust has partially replaced with fine aggregate in concrete and significant improvement has witnessed 4 5 an attempt to partially replace quarry dust in place of sand in M35 grade concrete On experimentation it was found that the partial replacement of sand with 10 of quarry du st has given the optimum results Therefore t his study recommends that if partial replacement of sand with quarry dust upto 10 in M35 grade of concrete

Get More

Strength and durability properties of quarry dust powder

Strength and durability properties of quarry dust powder

1 151 311for control concrete and 1 107 311for quarry dust concrete M50 grade Summary of the test result for concrete mixes with fully replacement of fine aggregate using quarry dust and Steel fiber as recorded in tables Fig 31Test result of cube compression International Journal of Innovations in Engineering and Technology IJIET Through reaction with the concrete admixture Marble sludge powder and quarry rock dust improved pozzolanic reaction microaggregate filling and concrete durability This paper presents the feasibility of the usage of quarry rock dust and marble sludge powder as hundred percent substitutes for natural sand in concrete

Get More

Use of Quarry Fine as Partial Replacement of Concrete

Use of Quarry Fine as Partial Replacement of Concrete

considerable amount of quarry dust is composed In this analysis the experiment work is performed by using cement fine aggregate coarse aggregate quarry dust The examples were casted for M25 grade of concrete by supplanting the cement 0 5 10 15 and 20 by quarry dust and tested for workability by slump test LITERATURE SURVEY Partial replacement of river sand with quarry dust has been successfully reported by Lohani et al 2012 the partial replacement of sand with quarry dust 0 20 30 40 and 50 for a design mix of M20 grade concrete Prachoom Khamput 2008 the possibility of 70100 replacement of sand with quarry dust in Thailand

Get More

Strength and Durabilitry of Fibre Reinforced Quarry Dust

Strength and Durabilitry of Fibre Reinforced Quarry Dust

due to depletion of river bed Quarry dust is a waste obtained during quarrying process It has very recently gained good attention to be used as an effective filler material instead of fine aggregate In the present study the hardened and durable properties of concrete using quarry dust were investigated for M60 grade concrete In this work the feasibility of the usage of quarry dust as 6040 proportion of substitution of natural sand ie quarry dust replaces 60 of natural sand in concrete Silica fume is added as mineral admixture by 15 of weight of cement and steel fiber used in different

Get More

Experimental Study on Use of Quarry Dust and Fly Ash

Experimental Study on Use of Quarry Dust and Fly Ash

Experimental study on partial replacement of cement with quarry dust Sairam The percentages of quarry dust partial replacement of cement in concrete are 0 10 15 20 25 30 35 and 40 M20 M30 M40 grade concrete cubes of 150x150x150mm size were cast for conducting compressive strength test Read more compressive strength of quarry dust concrete can be improved with admixture and also super plasticizers can be used to improve the workability of quarry dust replaced concrete 2 MATERIAL USED AND THEIR PROPERTIES 21 Materials used Ordinary Portland Cement 43 Grade conforming to IS 81121989 was used for the

Get More

2009 Properties Of Green Concrete Containing Quarry

2009 Properties Of Green Concrete Containing Quarry

found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10 more than the conventional concrete Suribabu et al 2015 In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days II From the results of the experimental study the following conclusions were drawn on concrete when quarry dust and fly ash are added in different proportions 1 With the addition of 15 of fly ash and 15 of quarry dust the compressive strength increases to 22 then control mix M40 grade at 28 days

Get More

density quarry dust kg m3 BINQ Mining

density quarry dust kg m3 BINQ Mining

Mar 07 2018 The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied M25 grade concrete was prepared with 0 The present study reports the suitability of quarry dust powder in the development of concrete building blocks by evaluating its strength durability acoustic and thermal properties Since the mixes showed very dry nature at higher percentages of M Sand replacement workability was kept in a constant range to find the optimum mix

Get More

PDF Study on Performance of Quarry Dust as Fine

PDF Study on Performance of Quarry Dust as Fine

Locally available well graded quarry dust conforming to ZoneII having specific gravity 268 and fineness modulus 270 was used as fine aggregate Metakaolin with specific gravity 25 was used to replace cement at 5 10 15 and 20 by weight of cement Crushed stone is produced by crushing quarry rock boulders cobbles or largesize gravel Crushed aircooled blastfurnace slag is also used as fine or coarse aggregate The aggregates are usually washed and graded at the pit or plant Some variation in the type quality cleanliness grading moisture content and other properties is expected

Get More
Recent Posts